OFM4X4 Synthetic Winch Rope 6mm x 28m with Hook – Gray, 3200 kg

Gray synthetic winch rope 6 mm x 28 m with hook

A 28 m length of 6 mm synthetic plasma winch rope, finished with a hook. The safety case for synthetic is simple: it stores very little energy under tension, so if it parts it falls to the ground instead of whipping back through the air.

Technical specification

• Diameter: 6 mm
• Length: 28 m
• Colour: Gray
• Material: UHMWPE (ultra-high-molecular-weight polyethylene)
• Tensile strength: 3200 kg
• Hook: Included
• Outer layer: Polyurethane sheath
• Weight: 1 kg

Why synthetic rope beats steel cable

• Safer under failure: stores almost no energy, so a parted line drops rather than recoiling
• Six times lighter: easy to pull out to a distant anchor by hand
• Stronger for its weight: around 70% stronger than steel cable of the same diameter
• No sharp strands: no broken wires to tear gloves and hands
• Unaffected by oil and water: no loss of performance when soaked
• Floats and stays flexible in wet and cold conditions
• Minimal stretch under load for predictable, controlled pulls

Protective sheath

The polyurethane outer layer holds the rope’s round profile and takes the abrasion when the line drags over rock or a sharp edge, which is by far the most common way synthetic rope gets destroyed.

Fitting and care

Synthetic rope must run through a hawse fairlead – roller fairleads have edges and pinch points that will cut it. Keep the rope away from hot exhaust components, wind it back onto the drum under light tension so the wraps bed evenly, and rinse mud and grit out after a wet recovery.

Safety

Always lay a recovery damper over the line during a pull, keep bystanders well outside the danger zone, and never step over a loaded line.